聚丁二酸丁二醇酯/聚乙二醇硬脂酸酯共混物结晶行为
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

四川省科技支撑计划项目(2016FZ0033);泸州市科技计划项目(2016-S-63(1/3)


Crystallization Behavior of Poly(butylene succinate) and Polyethylene Glycol Stearate Blends
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    用溶液共混的方法制备了聚丁二酸丁二醇酯(PBS)/聚乙二醇硬脂酸酯(PEOST)共混物。采用差示扫描量热法(DSC)表征了共混物的结晶熔融行为。研究结果表明,加入质量分数5%的PEOST能使PBS结晶温度(Tc)降低约10 ℃,但使熔融温度(Tm)升高约3 ℃,继续增加PEOST用量对PBS的Tc和Tm影响不大;PBS的结晶焓(ΔHc)随PEOST含量的增加呈上升趋势,而熔融焓(ΔHm)先降低再上升;PEOST的结晶属于受限结晶,当其质量分数低于10%,DSC曲线中没有出现PEOST的结晶峰和熔融峰;当质量分数大于20%时,才出现PEOST结晶峰和相应的熔融峰。傅里叶变换红外(FT-IR)谱图中也才出现相应的结晶红外响应峰(1107 cm-1和841 cm-1)。广角X射线衍射显示加入PEOST未改变PBS的晶体结构。偏光显微镜分析表明,PEOST含量较高的共混物晶体尺寸更大,具有更清晰的周期性明暗相间的环带花纹。

    Abstract:

    Poly(butylene succinate) (PBS) and polyoxyethylene stearate ( PEOST) blends were prepared by the method of solution blending. The crystallization behavior of the blends were studied by DSC. The results show that when the mass fraction of PEOST reaches 5% , the crystallization temperature (Tc) of PBS is reduced about 10 ℃, instead the melting temperature (Tm) of PBS is improved about 3 ℃. However, the more content of PEOST added has little effect on the Tc and Tm of PBS. The ΔHc of PBS increases with the increase of PEOST content, while the ΔHm decreases first and then increases. The crystallization of PEOST belongs to confined crystallization. When the mass fraction of PEOST is less than 10%, no PEOST crystallization and melting peaks appear in the DSC curves, but emerge as the content is more than 20%. Also both Tc and Tm increase with the increase of PEOST content. When the mass fraction of PEOST is greater than 20%, the infrared response peaks of the PEOST crystals appear in the infrared spectra (1107 cm-1 and 841 cm-1). WAXD shows that the crystal structures of PBS are not changed by PEOST added. POM shows that the PBS crystal size in the blends with higher PEOST content is larger, and the characteristics of the spherulites are more obvious.

    参考文献
    相似文献
    引证文献
引用本文

黄 勇,刘俊红,杨永斌.聚丁二酸丁二醇酯/聚乙二醇硬脂酸酯共混物结晶行为[J].高分子材料科学与工程,2019,35(2):91-96.

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 录用日期:
  • 网络出版日期:
  • 在线发布日期: 2019-03-07
  • 出版日期:
您是第      位访问者
编辑出版 :《高分子材料科学与工程》编辑部
地址 :四川省成都市一环路南一段24号 四川大学高分子研究所
电话 :028-8540 1653  E-mail:gfzclbjb@163.net; gfzclbjb@vip.sina.com
高分子材料科学与工程 ® 2024 版权所有
技术支持:北京勤云科技发展有限公司